降温速率对硫酸钠溶液晶体析出影响的试验研究

doi:10.7522/j.issn.1000-0240.2016.0048

冰川冻土 ›› 2016, Vol. 38 ›› Issue (2): 431-437.doi: 10.7522/j.issn.1000-0240.2016.0048

降温速率对硫酸钠溶液晶体析出影响的试验研究

万旭升^{1 2}, 赖远明¹

1. 中国科学院寒区旱区环境与工程研究所冻土工程国家重点实验室, 甘肃兰州 730000;
2. 西南石油大学土木工程与建筑学院, 四川成都 610513

收稿日期:2015-11-13 修回日期:2016-01-25 出版日期:2016-04-25 发布日期:2016-07-13
通讯作者: 赖远明,E-mail:ymlai@lzb.ac.cn E-mail:ymlai@lzb.ac.cn
作者简介:万旭升(1987-),男,甘肃静宁人,讲师,2015年在中国科学院寒区旱区环境与工程研究所获博士学位,主要从事寒区工程数值模拟与计算.E-mail:xinyanwanxxusheng@163.com
基金资助:
国家自然科学基金项目（41230630）；中国科学院西部行动计划项目（KZCX2-XB3-19）；西南石油大学青年教师“过学术关”项目（201599010104）资助

Experimental study on the influence of cooling rate on salt crystallizing in sodium sulfate solution

WAN Xu sheng^{1 2}, LAI Yuanming¹

1. State Key Laboratory of Frozen Soil Engineering, Cold and Arid Regions Environmental and Engineering Institute, Chinese Academy of Sciences, Lanzhou 730000, China;
2. School of Civil Engineering and Architecture, Southwest Petroleum University, Chengdu 610513, China

Received:2015-11-13 Revised:2016-01-25 Online:2016-04-25 Published:2016-07-13

摘要/Abstract

摘要： 为探讨硫酸钠盐渍土盐胀机理，研究了十水硫酸钠晶体在硫酸钠溶液中的析出规律.针对不同浓度的硫酸钠溶液，在1℃·min^-1、0.1℃·min^-1和0.02℃·min^-13种降温速率下，通过降温试验对晶体初始析出温度进行观测.试验表明：十水硫酸钠晶体的析出受降温速率的影响，随着降温速率的减小，晶体初始析出温度升高；降温速率的大小对晶体析出后溶液浓度变化几乎没有影响，但其会影响晶体形态，降温速率越小，晶体形态更为稳定；晶体析出受到相变驱动力作用，相变驱动力与降温速率大小呈正比，降温速率越大，晶体初始析出结晶力越大.

关键词: 硫酸钠溶液, 盐胀, 晶体析出, 降温速率, 相变驱动力

Abstract: Based on the pull down test of sodium sulfate solution, the crystallization law of sodium sulfate decahydrate was studied to explore the mechanism of sodium sulfate saline soil. In our experiment, the initial crystallization temperatures of different concentration of sodium sulfate solutions were observed under three kinds of cooling rate, which are 1℃·min^-1, 0.1℃·min^-1 and 0.02·min^-1 respectively. The results show that the crystallization of sodium sulfate decahydrate is affected by the cooling rate, the initial crystallization temperature increases as the cooling rate decreases. The effect of value of cooling rate on concentration changing is very little, but it would affect crystal morphology, the lower the cooling rate, the more stable the crystal morphology. Moreover, salts begin to crystallize under the effect of the phase transformation driving force, it is proportional to the value of cooling rate, the higher the cooing rate, the larger initial crystallization force.

Key words: sodium sulfate solution, salt expansion, crystallization, cooling rate, drive force of phase change

中图分类号:

TU448

万旭升, 赖远明. 降温速率对硫酸钠溶液晶体析出影响的试验研究[J]. 冰川冻土, 2016, 38(2): 431-437.

WAN Xu sheng, LAI Yuanming. Experimental study on the influence of cooling rate on salt crystallizing in sodium sulfate solution[J]. JOURNAL OF GLACIOLOGY AND GEOCRYOLOGY, 2016, 38(2): 431-437.

参考文献

[1] Luo Weifu. Highway engineering in saline soil regions[M]. Beijing:China Communications Press, 1980.[罗伟甫. 盐渍土地区公路工程[M]. 北京:人民交通出版社, 1980].
[2] Yang Xifeng, You Zhemin, Niu Fujun, et al. Research progress in stabilizers and their effects in improving physical and mechanical properties of saline soil[J]. Journal of Glaciology and Geocryology, 2014, 36(2):376-385.[杨西锋, 尤哲敏, 牛富俊, 等. 固化剂对盐渍土物理力学性质的固化效果研究进展[J]. 冰川冻土, 2014, 36(2):376-385].
[3] Niu Jiangyu, Jin Pengwei, Li Dongwei, et al. Study of the uniaxial compressive strength of frozen saline sandy soil[J]. Journal of Glaciology and Geocryology, 2015, 37(2):428-433.[牛江宇, 靳鹏伟, 李栋伟, 等. 冻结盐渍砂土单轴强度特性研究[J]. 冰川冻土, 2015, 37(2):428-433].
[4] Zhang Ying, Bing Hui. Study of the physical and mechanical properties of saline frozen soil;Research status and progress[J]. Journal of Glaciology and Geocryology, 2013, 35(6):1527-1535.[张英, 邴慧. 含盐冻土物理学性质研究现状与进展[J]. 冰川冻土, 2013, 35(6):1527-1535].
[5] Xu Xuezu, Wang Jiacheng, Zhang Lixin. Frozen soil physics[M]. Beijing:Science Press, 2010:1-396.[徐学祖, 王家澄, 张立新. 冻土物理学[M]. 北京:科学出版社, 2010:1-396].
[6] Steiger M, Asumssen S. Crystallization of sodium sulfate phases in porous materials:The phase diagram Na₂SO₄-H₂O and the generation of stress[J]. Geochimica et Cosmochimica Acta, 2008, 72:4291-4306.
[7] Chen Xiaobei, Liu Jiankun, Liu Hongxu, et al. Frost action of soil and foundation engineering[M]. Beijing:Science Press, 2006:1-532.[陈肖柏, 刘建坤, 刘鸿绪, 等. 土的冻结作用与地基[M]. 北京:人民出版社, 2006:1-532].
[8] Deng Yousheng, Zhou Chenglin. Salt expansion and frost heave of sodium sulphate solution[J]. Journal of Glaciology and Geocryology, 2009, 31(5):920-924.[邓友生, 周成林. 硫酸钠溶液的盐胀与冻胀[J]. 冰川冻土, 2009, 31(5):920-924].
[9] Niu Xirong, Gao Jiangping. Deduction of salt expansion expression during pure salt expansion period of sulfate saline soil[J]. Chinese Journal Geotechnical Engineering, 2008, 30(7):1058-1061.[牛玺荣, 高江平. 硫酸钠盐渍土纯盐胀关系式的建立[J]. 岩土工程学报, 2008, 30(7):1058-1061].
[10] Koniorczyk M. Modeling the phase change of salt dissolved in pore water-Equilibrium and non-quilibrium approach[J]. Construction and Biulding Materials, 2010, 24:1119-1128
[11] Wan Xusheng, Lai Yuanming. Experimental study on freezing temperature and salt crystal precipitation of sodium sulphate solution and sodium sulfate saline soil[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(11):2090-2096.[万旭升, 赖远明. 硫酸钠溶液和硫酸钠盐渍土的冻结温度及盐晶析出试验研究[J]. 岩土工程学报, 2013, 35(11):2090-2096].
[12] Lai Yuanming, Wan Xusheng, Zhang Mingyi. An experimental study on the influence of cooling rates on salt[J]. Cold Regions Science and Technology, 2016, 124:67-76.
[13] Zhang Kecong. Modern crystallography[M]. Beijing:Science Press, 2011:1-582.[张克从. 近代晶体学[M]. 北京:科学出版社, 2011:1-582].
[14] Espinosa R M, Franke L, Deckelmann G. Phase changes of salts in porous materials:crystallization, hydration and deliquescence[J]. Construction and Building Materials, 2008, 22:1758-1773.
[15] Chatterji S, Thaulow N. Unambiguous demonstration of de-structive crystal growth pressure[J]. Cement and Concrete Research, 1997, 27(6):811-816.
[16] Prausnitz J M, Lichtenthaler N R, De Azevedo E G. Molecular thermodynamics of fluid-phase equilibria[M]. 3rd ed. Prentice Hall PRT, 1999:1-864.
[17] Steiger M. Crystal growth in porous materials:The crystallization pressure of large crystals[J]. Journal of Crystal Growth, 2005, 282:455-469.
[18] Derluyn H. Salt transport and crystallization in porous limestone:Neutron-X-Ray Imaging and poromechanical modeling[D]. Zürich:University of Zurich, 2012.
[19] Okorafor O C. Solubility and density isotherms for sodium sulfate-water-methanol system[J]. Journal of Chemical and Engineering Data, 1999, 44:488-490.
[20] Xu Xuezu, Wang Jiacheng, Zhang Lixin, et al. Mechanisms of Frost Heave and Soil Expansion of Soils[M]. Beijing:Science Press, 1995:1-126.[徐学祖, 王家澄, 张立新, 等. 土体的冻胀和盐胀机理[M]. 北京:科学出版社, 1995:1-126].

降温速率对硫酸钠溶液晶体析出影响的试验研究

Experimental study on the influence of cooling rate on salt crystallizing in sodium sulfate solution

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 1

[1]	陈继, 李昆, 盛煜, 冯子亮. 季节冻土区埋地管道水温的变化规律及其影响因素分析[J]. 冰川冻土, 2014, 36(4): 836-844.
[2]	张英, 邴慧*. 含盐冻土物理力学性质研究现状与进展[J]. 冰川冻土, 2013, 35(6): 1527-1535.
[3]	邓友生;周成林. 硫酸钠溶液的盐胀与冻胀[J]. 冰川冻土, 2009, 31(5): 920-924.
[4]	丁兆民;张莎莎;杨晓华. 粗颗粒盐渍土路用填料可用性指标研究[J]. 冰川冻土, 2008, 30(4): 623-631.
[5]	宋启卓, 陈龙珠. 人工神经网络在盐渍土盐胀特性研究中的应用[J]. 冰川冻土, 2006, 28(4): 607-612.
[6]	邴慧, 何平, 杨成松, 施烨辉. 开放系统下硫酸钠盐对土体冻胀的影响[J]. 冰川冻土, 2006, 28(1): 126-130.
[7]	吴青柏, 孙涛, 陶兆祥, 李强. 恒温下含硫酸钠盐粗颗粒土盐胀特征及过程研究[J]. 冰川冻土, 2001, 23(3): 238-243.
[8]	褚彩平, 李斌, 侯仲杰. 硫酸盐渍土在多次冻融循环时的盐胀累加规律[J]. 冰川冻土, 1998, 20(2): 108-111.
[9]	高民欢, 李斌, 金应春. 含氯盐和硫酸盐类盐渍土膨胀特性的研究[J]. 冰川冻土, 1997, 19(4): 346-353.
[10]	彭铁华, 李斌. 硫酸盐渍土在不同降温速率下的盐胀规律[J]. 冰川冻土, 1997, 19(3): 252-257.
[11]	杨丽英, 李斌. 氯与硫酸根比值对硫酸盐渍土工程性质影响的研究[J]. 冰川冻土, 1997, 19(1): 84-89.
[12]	高江平, 吴家惠, 邓友生, 王家澄. 硫酸盐渍土膨胀规律的综合影响因素的试验研究[J]. 冰川冻土, 1996, 18(2): 170-177.
[13]	郭德发 . 新疆地区水工建筑物冻害防治概述[J]. 冰川冻土, 1996, 18(1): 88-92.
[14]	费雪良, 李斌, 王家澄. 不同密度硫酸盐渍土盐胀规律的试验研究[J]. 冰川冻土, 1994, 16(3): 245-250.
[15]	陈肖柏, 邱国庆, 王雅卿, 盛文坤. 温降时之盐分重分布及盐胀试验研究[J]. 冰川冻土, 1989, 11(3): 231-238.